TRI-ESS SCIENCES
1020 W. CHESTNUT STREET, BURBANK, CA 91506
24 hour Emergency: 800-535-5053

MATERIAL SAFETY DATA SHEET (MSDS)

SECTION I

PRODUCT NAME: ROAD BURN
CHEMICAL NAME: AMYL ACETATE/ETHYL ALCOHOL

SECTION II – HAZARDOUS INGREDIENTS

CHEMICAL NAMES             CAS NUMBERS             EXPOSURE LIMITS IN AIR
                                                                                ACGIH TIV    OSHA PEL
AMYL ACETATE                     628-63-7                     125ppm
ETHYL ALCOHOL                   64-17-5                        1000ppm

SECTION III – PHYSICAL DATA

VAPOR DENSITY (air=1): 4.0
BOILING POINT (° F): 295° F         EVAPORATION RATE (butyl acetate=1): 0.42
MELTING POINT: -148° F              SOLUBILITY IN WATER: 0.2%
SPECIFIC GRAVITY: 0.876            VAPOR PRESSURE, mmHg at 20° C: 5.0
APPEARANCE: Clear, colorless liquid, mild characteristic banana odor.

SECTION IV – FIRE & EXPLOSION HAZARD DATA

FLASH POINT: 91cc
AUTOIGNITION TEMPERATURE: 700° F
FLAMMABLE LIMITS: LOWER (LEL): 1.1 UPPER (UEL): 7.5
EXTINGUISHING MEDIA: WATER SPRAY, FOAM, CARBON DIOXIDE AND DRY CHEMICALS.

SPECIAL FIREFIGHTING PROCEDURES: AVOID STRAIGHT STREAM OF WATER AS THIS MAY SPREAD FIRE

UNUSUAL FIRE AND EXPLOSION HAZARDS: VAPOR EXPLOSION HAZARDS

SECTION V – HEALTH HAZARD DATA

SYMPTOMS OF OVER EXPOSURE:

INHALED: THROAT IRRITATION, NAUSEA, HEADACHE, DIZZINESS
CONTACT WITH SKIN OR EYES: IRRITATING
ABSORBED THROUGH SKIN: NO APPRECIABLE HAZARD
SWALLOWED: LOW ORAL TOXICITY, LD 50 = 6.5g/Kg (rat)

HEALTH EFFECTS OR RISKS FROM EXPOSURE:
ACUTE: IRRITATION, AS ABOVE
CHRONIC: NO LONG TERM EFFECTS DOCUMENTED

EMERGENCY AND FIRST AID PROCEDURES:
EYE CONTACT: FLUSH COPIOUSLY WITH WATER
SKIN CONTACT: FLUSH COPIOUSLY WITH WATER
INHALATION: IMMEDIATELY MOVE TO FRESH AIR. GIVE OXYGEN IF BREATHING IS DIFFICULT. GIVE ARTIFICIAL RESPIRATION, IF NECESSARY
INGESTION: CALL FOR MEDICAL ASSISTANCE IS SYMPTOMS ARE SEVERE.

SUSPECTED CANCER AGENT?
NO, THIS PRODUCT’S INGREDIENTS ARE NOT FOUND IN THE LISTS BELOW
FEDERAL OSHA NTP IARC

California employers using Cal/OSHA – regulated carcinogens must register with Cal/OSHA. The Cal/OSHA and Federal OSHA carcinogens lists are similar.

SECTION VI – REACTIVITY DATA

STABILITY: STABLE
CONDITIONS TO AVOID: HEAT & IGNITION SOURCES TO BE AVOIDED
INCOMPATIBILITY (Materials to avoid): STRONG ALKALIES OR ACIDS

HAZARDOUS DECOMPOSITION PRODUCTS (including combustion products):
THERMAL DECOMPOSITION YIELDS ACRID SMOKE AND IRRITATING VAPORS. INCOMPLETE COMBUSION MAY YIELD CO2.
HAZARDOUS POLYMERIZATION: WILL NOT OCCUR
CONDITIONS TO AVOID: NONE

SECTION VII – SPILL, LEAK AND DISPOSAL PROCEDURES

SPILL RESPONSE PROCEDURES (include employee protection measures):
TAKE UP WITH SOLID NON-COMBUSTIBLE ADSORBENTS FOR DISPOSAL. USE CHEMICAL CANISTER RESPIRATOR OR SELF-CONTAINER AIR.

PREPARING WASTES FOR DISPOSAL:
PLACE SOLIDIFIED WASTE IN STEEL CONTAINERS FOR DISPOSAL

NOTE: Dispose of all wastes in accordance with federal, state and local regulations.

VENTILATION AND ENGINEERING CONTROLS:
PROVIDE ADEQUATE VENTILATION TO PREVENT CONCENTRATION BUILD-UP.
RESPIRATORY PROTECTION: CHEMICAL CANISTER OR SELF-CONTAINED BREATHING AIR
EYE PROTECTION: GOGGLES
GLOVES: RUBBER OR POLYETHYLENE
OTHER PROTECTIVE EQUIPMENT: PROTECTIVE CLOTHING, SAFETY SHOWER
WORK PRACTICES, HYGIENIC PRACTICES: AVOID INHALATION OF VAPORS AND CONTACT WITH SKIN AND EYES

OTHER HANDLING AND STORAGE REQUIREMENTS: STORE IN COOL PLACE AWAY FROM POSSIBLE IGNITION SOURCE.

PROTECTIVE MEASURES DURING MAINTENANCE OF CONTAMINATED EQUIPMENT
AS ABOVE

DATE PREPARED: MAY 20, 1987

While Tri-Ess Sciences Inc. believes the information set forth herein is accurate as of the date thereof, Tri-Ess Sciences Inc. makes no warranty with respect thereto and expressly disclaims all liability for reliance thereof, such data is offered solely for your consideration, investigation and your verification.